TMS320F28335: Probable causes of failure.

JAGATHRAJ B N

Prodigy 70 points

Part Number: TMS320F28335

3.3GND short 1.9V GND 1.9V & GND short U8 DSP failed.

over 9 years ago

0 Gautam Iyer over 9 years ago

Guru 192875 points

Hi JR,

Can you first de-solder the chip and then check for the short on the board?

Regards,
Gautam

0 JAGATHRAJ B N over 9 years ago in reply to Gautam Iyer

Prodigy 70 points

This chip was working while loading programming and when we started for testing the PCB we noticed that DSP failed(short)

0 Adam Dunhoft over 9 years ago in reply to JAGATHRAJ B N

TI__Expert 7885 points

Hello,

It sounds like the device was damaged at some point during your testing. It would be good if you could remove the device and test the nodes on the PCB to see if the shorts are on the PCB or limited to the device. Do you have the ability to remove the device from the board?

Best Regards,
Adam Dunhoft

0 JAGATHRAJ B N over 9 years ago in reply to Adam Dunhoft

Prodigy 70 points

We have removed and checked no short observed in PCB

0 JAGATHRAJ B N over 9 years ago in reply to Adam Dunhoft

Prodigy 70 points

We are using "XDS510 USB, USB to JTAG Programmer" is this recommended ?

0 Vivek Singh over 9 years ago in reply to JAGATHRAJ B N

TI__Guru** 117001 points

We are using "XDS510 USB, USB to JTAG Programmer" is this recommended ?

Yes, this emulator should work.

Vivek Singh

0 JAGATHRAJ B N over 9 years ago in reply to Vivek Singh

Prodigy 70 points

We are using OLIMEX TMS320-JTSG-USB XDS100-V2 . Is it recommended?
And we got to know that we have received TMS320F28335 from below source . is this authorized source?

Sales Order Number (SO#): -- 1901870
Delivery Document Number (DN#) -- Inv # 4722617 dt 13.12.2016
Purchase Order Number (PO#) -- STPL/I/SKY/5427
Distributor Name: -- Element14 Pte Ltd
Distributor Site / Location: -- Singapore
Distributor Contact E-Mail: -- GSarangan@element14.com
Address: -- Geetha

#24, 2nd floor, North road,

C.I.T.Nagar,

Chennai--600035

T: + 91 44 43838510

0 JAGATHRAJ B N over 9 years ago in reply to JAGATHRAJ B N

Prodigy 70 points

We are using OLIMEX TMS320-JTSG-USB XDS100-V2 . Is it recommended?

0 JAGATHRAJ B N over 9 years ago in reply to JAGATHRAJ B N

Prodigy 70 points

And we got to know that we have received TMS320F28335 from below source . is this authorized source?

Sales Order Number (SO#): -- 1901870
Delivery Document Number (DN#) -- Inv # 4722617 dt 13.12.2016
Purchase Order Number (PO#) -- STPL/I/SKY/5427
Distributor Name: -- Element14 Pte Ltd
Distributor Site / Location: -- Singapore
Distributor Contact E-Mail: -- GSarangan@element14.com
Address: -- Geetha

#24, 2nd floor, North road,

C.I.T.Nagar,

Chennai--600035

T: + 91 44 43838510

0 Vivek Singh over 9 years ago in reply to JAGATHRAJ B N

TI__Guru** 117001 points

Yes, this emulator should be fine.

C2000™︎ microcontrollers

C2000 microcontrollers forum

TMS320F28335: Probable causes of failure.